Order Arizona Oversize Permits Online Now!
Arizona Oversize Overweight permits Rules and Regulations
Arizona Oversize/Overweight permits Validity: Oversize permits issued in Arizona remain valid for a total of four consecutive days. Drivers are required to secure the permit before entering the state.
Arizona Traveling Time with Oversize Load: Travel during daylight is allowed in Arizona for vehicles wider than 10 feet, taller than 14′-6″, or with a rear overhang over 10 feet. Daylight is defined as 30 minutes before sunrise to 30 minutes after sunset. Loads up to 16′ in width, 16′ in height, 120′ in length, and 250,000 lbs. may travel on approved routes from 3:00 a.m. to noon on weekends (except during holidays or curfew hours). Request for this must be made during permit application. Loads wider than 11′ require a pilot car for weekend travel in this time frame; loads over 15′ in height need a height pole escort.
Note for Overweight Permits in Arizona: Arizona weighing stations require that the acceptable weight and dimensions be nearly identical to the actual measurements. To avoid difficulties, get permits straight from the scale or confirm that the weight mentioned on the permit corresponds to the actual load.
Arizona Travel Restrictions: In Arizona, oversize or overweight travel is restricted during peak hours on I-17, I-10, and SR 60 in Phoenix, and I-10 or I-19 in Tucson from 7:00 AM to 9:00 AM and from 4:00 PM to 6:00 PM. A “courtesy permit” or city route approval may be needed.
Arizona Holiday Restriction: Movement of oversize loads is not allowed on major holidays including New Year’s Day, Memorial Day, Independence Day, Labor Day, Thanksgiving Day, and Christmas Day
Arizona Road/Bridge Restriction with Oversize Load: Arizona does not specify individual bridge restrictions as these are governed by the Federal Bridge Formula. However, the following road-related restrictions apply:
- Traveling through construction zones
- Ignoring warning signals in work areas
Failure to yield to emergency or law enforcement vehicles can result in fines or further action.
Oversize load Seasonal Restriction in Arizona: Although frost laws are enforced in many Canadian provinces and U.S. states, Arizona does not have any specific seasonal weight limits. However, such conditions may be reflected in Arizona oversize load permits depending on the load’s characteristics and classification
Arizona Oversize Tire Regulations:
Tires must be in good operating condition, properly inflated, and have a minimum tread depth of 2/32″ (4/32″ for steering axles).
Tires must not have protrusions made of materials other than rubber unless required for safety purposes.
Chain Requirements: The use of tire chains is allowed when necessary for safety due to snow, ice, or other slippery road conditions
Oversize load Seasonal Restriction in Alabama: While frost laws apply in many northern states and Canadian provinces, Alabama does not impose specific seasonal restrictions for oversize loads. However, weather-related limitations may still be specified within the conditions of an issued oversize permit depending on the type and nature of the load.
Alabama Oversize Tire Regulations: Tires must be in proper working condition, adequately inflated, and have a minimum tread depth of 2/32 of an inch. No protruding objects or materials (other than rubber) are allowed on the tires unless required for safety purposes. Each tire must have a continuous rubber tread surface at least four inches wide and extending at least one inch beyond the outer edge of the tread on all sides.
Arizona Legal Dimensions/Size Limit
Arizona Legal Length: 57 feet for trailer on interstate. For semi-trailers longer than 53 feet on non-designated roads, total length must not exceed 65 feet
Overhang:
- 3 feet overhang for front.
- 6 feet overhang for rear
Arizona Wide Load Limit: 8 feet 6 inches
Arizona Legal Height: 14 feet
Arizona Legal Weight Limit: 80,000lbs gross weight
- Single Axle: 20,000lbs.
- Tandem Axles: 34,000lbs.
- Tridem Axles: 42,000lbs.
Maximum Load Dimensions with permits in Alabama
Length: 120 feet.
Width: 14 feet
Arizona Wide Load Requirements
- Permit Required: Loads over 8′-6″ wide (or 8′ wide on roads narrower than 12′) must be permitted.
- Flags: Red or fluorescent orange 18-inch square flags on all extremities.
- Banners/Signs: Oversize loads wider than 9′ must have appropriate signage reading “Oversize Load.”.
- Escort Vehicles: One front escort for width over 14 feet, one front and one rear escort for width over 12 feet.
Arizona Wide Load Restrictions
- Travel Time: 10 feet wide allowed from 30 minutes before sunrise to 30 minutes after sunset. over 14′ wide may travel on interstates from 3:00 a.m. to noon on weekends.
- Holiday Restrictions: No movement on New Year’s Day, Memorial Day, Independence Day, Labor Day, Thanksgiving, or Christmas
Height: 16 feet
Weight:
Weight Limits Under Routine Permits:
- Single axle: 28,000 pounds.
- Tandem axles: 46,000 pounds.
- Tridem axles: 51,450 pounds to 53,974 pounds.
Tandem and tridem axles have different spacing and widths. For example, a tridem axle configuration with 9 feet of spacing (4 feet and six inches between each) and a 8-feet axle width could handle up to 51,450 pounds.
Note for Overweight Permits in Arizona:
Arizona weighing stations require that the acceptable weight and dimensions be nearly identical to the actual measurements. To avoid difficulties, get permits straight from the scale or confirm that the weight mentioned on the permit corresponds to the actual load.
Note: A “Class C Tridem Permit” is needed to move the loads weighing up to 59,168 pounds having axle spacing of 9 feet. Maximum allowable weight for 8′ axle spacing is 57,960 pounds; for 10′ spacing, it increases to 60,000 pounds. This permit is only authorized for travel on Interstates 10, 19, and 40, as well as certain parts of SR68 and US93 heading to the Nevada border. Any deviation, including diversions, will invalidate the permission.
A “Class C” permit is required for transporting loads with a total weight of 250,000 pounds and dimensions reaching 14 feet in width, 16 feet in height, and 120 feet in length. In some instances, a route survey may be necessary
What Are The Requirements For a Pilot Car In Arizona
Length: More than 120 feet–1 or more Pilot Cars
Overhang: Greater than 20 feet (front or rear) require one pilot car
Width: Loads wider than 14 feet require one or more pilot cars
Note: Depending on the road’s unique limitations, many limited routes need two pilot cars for trucks wider than 12 feet or loads higher or wider than 10 feet.
Height: Loads exceeding 16 feet in height must be escorted by one or more pilot vehicles
Note: For weekend travel between 3:00 AM and noon, any load wider than 11′ must be accompanied by a pilot car. If the load height exceeds 15′, a pilot vehicle equipped with a height pole is required.
Signage, Flashing Amber lights and flags Requirements and Arizona Additional Information
Signage, Flashing Amber Lights and Flags:
- Trucks and loads wider than 9 feet have to display “Oversize Load” signs to ensure clear identification.
- Loads that are overweight or overheight only do not need signage or flags.
- Any load or vehicle that exceeds the allowed width limitations must be marked with red flags that are at least 12 inches square to guarantee visibility.
- Overhangs in the front or rear of the truck must either be flagged or illuminated to warning.
- Night movement is acceptable for loads with overhangs up to 10 feet, as long as they are flagged and lit
Additional Information:
- Blades and arms on bulldozers wider than 14′ (measured perpendicular to trailer wheels) must be removed and transported safely.
- Blades under 14′ wide may stay attached if raised and properly secured.
- Things like buckets, blades, or counterweights should be removed if possible, but if not, they may be transported with the load.
- If total weight exceeds legal limits, blades may remain on the same trailer as the dozer, but this must be mentioned on the permit.
- For wide loads, the vehicle’s side mirrors must be adjusted to ensure that the driver’s view is not obstructed by the load.
Arizona Oversize/Overweight Permit fee:
Arizona offers a variety of permits depending on the load type, dimensions, and weight. Permit costs range from as low as $12 for basic single-trip permits to more than $1,500 for annual permits involving both oversize and overweight configurations.
Single-Trip Permits (Oversize/Overweight):
- Single-Trip Permit Fees: Permit costs for one-time travel within Arizona vary based on the type of vehicle and the nature of the load:
• Oversize-only single-trip permit: $15
• Overweight-only single-trip permit: $75
• Combined oversize and overweight single-trip permit: $75Class C Single-Trip Permit Rates:
• Legal weight and under 18 feet in height or width: $30
• Legal weight loads over 18 feet in height or width are subject to a $40 fee
• Overweight and under 18 feet high/wide (over 80,000 lbs): $90
• Loads over 80,000 pounds and exceeding 18 feet high or wide must pay $100
• Mileage-Based Fees for Single-Trip Travel:
• For commercial vehicles with a Gross Vehicle Weight Rating (GVWR) of 12,000 pounds or more:
$12 for trips under 50 miles
$48 for trips over 50 miles
For vehicles such as road tractors, truck tractors, standard trucks, and passenger-carrying units with a GVWR above 26,000 pounds:
$15 for trips under 50 miles
$65 for trips over 50 miles
Note: These permits remain valid for 96 hours or until the vehicle exits Arizona. - Annual Permit Fees: Arizona also provides annual permits for continued operations. These are suitable for carriers operating frequently within the state.
• Annual oversize permit: $360
• Annual oversize and overweight permit: $600
Annual permits are applicable only if the vehicle stays within specific limitations:
Maximum gross weight: 250,000 pounds
Maximum width: 14 feet
Maximum height: 16 feet
Maximum length: 120 feet
Minimum axle count: 4• A per-trip usage fee is required even with annual permits:
$750 for oversize-only loads
A $1,500 fee applies to loads that are both oversize and overweight - Trip Permits (IRP Registration): Arizona issues temporary trip permits for commercial carriers registered in other states or jurisdictions. These permits are essential for operating in Arizona without a permanent registration.
• Available for durations of 30, 60, or 90 days
• Applies only to vehicles registered out-of-state
• The actual vehicle weight must not exceed the declared weight - Fuel Permits (IFTA Requirements): Fuel permits are required for diesel-powered commercial vehicles or vehicle combinations meeting the following criteria:
• GVWR exceeding 26,000 pounds
• Equipped with three or more axles
The permit fee depends on its duration, with rates ranging from $130 to $780. - Specialty Permits in Arizona: Special permits may be required based on the size or weight of the cargo. These include:
• Class C Permits: Mandatory for hauling exceptionally large or heavy loads:
Weight over 250,000 pounds
Length exceeding 120 feet
Height above 16 feet
Width exceeding 14 feet
• “Easy” C Mobile Home Permits: This simplified version of the Class C permit is tailored for mobile home transport and does not require a bridge engineering review. Eligibility requirements include:
Width up to 16 feet
Height up to 16 feet
Length up to 120 feet
Weight up to 80,000 pounds
Oversize and Overweight Fines in Arizona: In Arizona, penalties for oversize or overweight loads begin at $100 and may exceed $1,400. The total fine amount depends on how much the load surpasses the legal weight limit and whether the violation is a repeat offense within the same calendar year
FAQ’s
You can contact at (270)908-9656 Express Heavy Haul for Arizona Oversize Permits.
In Arizona, a vehicle or load is considered oversize if it exceeds the following legal dimensions: width over 8 feet
6 inches, height over 13 feet 6 inches, length over 65 feet for non-designated routes, or weight over 80,000
pounds gross.
A single-trip wide load permit in Arizona generally costs around $15. Additional fees may apply based on the
size, weight, and route of the load. Complex or heavier loads may result in increased permit charges
Yes, Arizona does accept electronic oversize and overweight permits. Carriers can either print the permit or
present it electronically to enforcement officers, provided it is accessible at all times during transport.
Oversize loads in Arizona are typically allowed to travel from 30 minutes before sunrise to 30 minutes after
sunset, Monday through Friday. On weekends, travel is usually permitted from 3:00 a.m. to noon on Saturdays
and Sundays, excluding holidays and curfew zones. Escort requirements may vary depending on load dimensions
The maximum legal height for a vehicle or load in Arizona without requiring an oversize permit is 13 feet 6 inches. Anything taller must obtain a height-specific oversize permit.
Oversize vehicles must comply with specified travel times and may be restricted from certain highways during
peak hours. Loads wider than 11 feet often require one or more pilot cars. Height poles are mandatory for loads
exceeding 15 feet in height. Specific routes and times are restricted, especially in major metro areas like Phoenix
and Tucson.
The cost of an oversize permit in Arizona typically starts at $15 for a single trip. However, the final cost depends
on the size, weight, type of vehicle, and mileage. Additional fees may apply for superloads or annual permits.
You can contact at (270)908-9656 Express Heavy Haul for Arizona Oversize Permits.
Arizona law defines an oversize vehicle as any that exceeds legal dimensions or weights. Operators must secure
a permit and follow designated routes, timing restrictions, and safety requirements, including the use of warning
signs, flags, and escorts when applicable.
An overweight permit in Arizona starts at approximately $75 for a single trip, depending on how much the
vehicle exceeds legal weight limits. Additional charges may be added for axle group configurations and total
gross weight.
Overweight violation fines in Arizona vary based on the amount by which the vehicle exceeds the limit. Fines
typically begin around $100 and can increase significantly with each 1,000 pounds over the limit. Serious
overweight violations may also result in the vehicle being detained until proper permits are obtained.
A 30-day temporary registration permit in Arizona, often used for unregistered vehicles or to allow interstate
movement, costs about $15. This fee is for temporary registration, not for oversize or overweight transport.
Generally, oversize loads are not permitted to travel at night in Arizona. Travel is usually limited to daylight
hours unless special arrangements or permits are obtained for nighttime movement, and only under specific
conditions and escort requirements.
In Arizona, pilot cars are required for loads exceeding 11 feet in width or 120 feet in length. Loads over 15 feet
in height must have a front escort with a height pole. Pilot vehicles must be equipped with proper signage,
amber lights, and two-way communication with the driver.
The maximum legal gross weight for commercial vehicles in Arizona is 80,000 pounds, unless operating under a
special permit. Axle weight limits must also be followed, such as 20,000 pounds for a single axle and 34,000
pounds for tandem axles
Get in Touch with Us
Lets Get Started
Get Your Arizona Oversize Permit - Trucking Permits
If your vehicle exceeds those numbers, it’s likely overweight or hauling an oversize load. Let Express Heavyhaul Trucking Permits help get you your Arizona oversize or overweight permit. State Direct. 24/7 Live Service. Order Online Today. Trip & Fuel Combo Permits. Types: Oversize, Overweight, Trip.
